Friction Characteristics of Impregnated and Non-Impregnated Graphite against Cemented Carbide under Water Lubrication

doi:10.1016/j.jmst.2016.06.013

材料科学与技术 ›› 2017, Vol. 33 ›› Issue (10): 1203-1209.DOI: 10.1016/j.jmst.2016.06.013

收稿日期:2016-02-02 修回日期:2016-05-16 接受日期:2016-06-14 出版日期:2017-10-25 发布日期:2018-01-25

Friction Characteristics of Impregnated and Non-Impregnated Graphite against Cemented Carbide under Water Lubrication

Zhang Gaolong, Liu Ying^*(), Guo Fei, Liu Xiangfeng, Wang Yuming

The State Key Laboratory of Tribology, Tsinghua University, Beijing 100084, China

Received:2016-02-02 Revised:2016-05-16 Accepted:2016-06-14 Online:2017-10-25 Published:2018-01-25
Contact: Liu Ying
About author:
1 These two authors contributed equally to this paper.

摘要/Abstract

Abstract:

The friction behavior of resin-impregnated and non-impregnated graphite sliding against a cemented carbide in dry, oil, and water environments using a ring-ring configuration was investigated. Friction coefficients were recorded at various speeds. The results showed that the impregnated graphite exhibited much better friction properties under water or oil lubrication than non-impregnated graphite, and the impregnated graphite could remain in the stable friction regime under high pressure × velocity (pv). Based on scanning electron microscopy and Raman spectroscopy analyses, the different characteristics between impregnated and non-impregnated graphite were able to be attributed to the structure of the graphite and wettability of the lubricants.

Key words: Friction, Resin-impregnated graphite, Non-impregnated graphite, Cemented carbide, Water lubrication

. [J]. 材料科学与技术, 2017, 33(10): 1203-1209.

Zhang Gaolong, Liu Ying, Guo Fei, Liu Xiangfeng, Wang Yuming. Friction Characteristics of Impregnated and Non-Impregnated Graphite against Cemented Carbide under Water Lubrication[J]. J. Mater. Sci. Technol., 2017, 33(10): 1203-1209.

图/表 9

Table 1 Mechanical and physical properties of test materials

Material	Young's modulus (GPa)	Hardness	Density (g/cm³)	Porosity (vol.%)	Thermal conductivity (W/(m K))
Cemented carbide	550	1500 HV	15	-	92
Non-impregnated graphite	18	60 HB	1.65	10	12
Impregnated graphite	24	80 HB	1.80	-	8

Fig. 1. Schematic diagram of the friction test apparatus.

Fig. 2. Speed-dependent friction coefficients of (a) non-impregnated graphite, and (b) impregnated graphite sliding against cemented carbide under a normal pressure of 0.3 MPa.

Fig. 3. SEM images of (a) non-impregnated graphite and (b) impregnated graphite. Schematic diagrams of the rubbing status of (c) non-impregnated graphite and (d) impregnated graphite.

Table 2 Contact angles of deionized water and PAO02 on different materials (unit: deg.)

Material	Deionized water	PAO02
Cemented carbide	41.14	7.07
Non-impregnated graphite	110.08	11.4
Impregnated graphite	79.73	9.44

Fig. 4. Morphologies of non-impregnated graphite (non-IG) under (a) dry, (b) water, and (c) oil lubrication, and impregnated graphite (IG) under (d) dry, (e) water, and (f) oil lubrication. Insets are EDX data for non-IG (left) and IG (right).

Fig. 5. SEM images of cemented carbide surfaces after sliding against non-impregnated graphite under (a) dry, (b) water, and (c) oil lubrication, and impregnated graphite under (d) dry, (e) water, and (f) oil lubrication.

Fig. 6. Raman spectra of (a) non-impregnated graphite and (b) impregnated graphite under different lubrication conditions. Insets are the magnification of G bands.

Fig. 7. Raman spectra of cemented carbide surfaces rubbed against (a) non-impregnated graphite, and (b) impregnated graphite under different lubrication conditions.

参考文献

[1]	W.L. Bragg, Introduction to Crystal Analysis, Bell,London, 1928, pp. 64.
[2]	J.V. Dobson, Electric J. 32(1935) 527-528.
[3]	R.H. Savage, J. Appl. Phys 19 (1948) 1-11.
[4]	F.P. Bowden, J.E. Young, Proc. R. Soc. London Ser. A 208 (1951) 444-455.
[5]	R.H. Savage, D.L. Schaefer, J. Appl. Phys 27 (1956) 136-138.
[6]	R.F. Deacon, J.F. Goodman, Proc. R. Soc. London Ser. A 243(1958)464-482.
[7]	B.K. Yen, B.E. Schwickert, M.F. Toney, Appl. Phys. Lett 84 (2004) 4702-4704.
[8]	J. Rietsch, P. Brender, J. Dentzer, R. Gadiou, L. Vidal, C. Vix-Gurterl, Carbon 55(2013) 90-97.
[9]	A.W. Batchelor, L.N. Lam, M. Chandrasekaran, Wear 198 (1996) 208-215.
[10]	J.A. Williams, J.H. Morris, A. Ball, Tribol. Int 30 (1997) 663-676.
[11]	P.V.K. Porgess, H. Wilman, Proc. Phys. Soc 76 (1960) 513.
[12]	H. Zaidi, H. Nery, D. Paulmier, Appl. Surf.Sci 70-1(1993) 180-185.
[13]	K. Jradi, M. Schmitt, S. Bistac, Appl. Surf. Sci 255 (2009) 4219-4224.
[14]	J.H. Jia, J.M. Chen, H.D. Zhou, J.B. Wang, H. Zhou, Tribol. Int 37 (2004) 423-429.
[15]	H. Hirani, S.S. Goikar, Wear 266 (2009) 1141-1154.
[16]	Q.F. Wen, Y. Liu, W.F. Huang, S.F. Suo, X.F. Liu, Y.M. Wang, Mater. Sci. Eng.Powder Metall 1 (2011) 6, in Chinese.
[17]	K. Bonny, P. De Baets, Y. Perez, J. Vleugels, B. Lauwers, Wear 268 (2010)1504-1517.
[18]	K. Bonny, P. De Baets, J. Vleugels, S.G. Huang, B. Lauwers, Tribol. Trans 52(2009) 481-491.
[19]	A.M. Human, H.E. Exner, Int. J. Refract. Met. Hard Mater 15 (1997) 65-71.
[20]	A.M. Human, H.E. Exner, Mater. Sci. Eng. Ser. A 209 (1996) 180-191.
[21]	S.Z. Wen, P. Huang, Principles of Tribology, 4th ed., Tsinghua University Press,Beijing, 2012, pp. 16-17.
[22]	Z.G. Zhu, S. Bai, J.F. Wu, L. Xu, T. Li, Y. Ren, C. Liu, J. Mater. Sci. Technol 31(2015) 325-330.
[23]	Z. Uchibori, H. Tanoue, H. Hirabayashi, J. Soc. Tribol. Lubr. Eng 46 (1990)163-171.
[24]	A. Senouci, J. Frene, H. Zaidi, Wear 225-229(1999) 949-953.
[25]	J.K. Xiao, L. Zhang, K.C. Zhou, J.G. Li, X.L. Xie, Z.Y. Li, Carbon 65 (2013) 53-62.
[26]	N. Kumar, R. Radhika, A.T. Kozakov, R. Pandian, S. Chakravarty, T.R. Ravindran,S. Dash, A.K. Tyagi, Appl. Surf. Sci 324 (2015) 443-454.
[27]	A. Sadezky, H. Muckenhuber, H. Grothe, R. Niessner, U. Poschl, Carbon 43(2005) 1731-1742.
[28]	Y. Wang, D.C. Alsmeyer, R.L. McCreery, Chem. Mater 2 (1990) 557-563.
[29]	S. Reich, C. Thomsen, Philos. Trans. A Math. Phys. Eng. Sci 362 (2004)2271-2288.
[30]	F. Tuinstra, J.L. Koenig, J. Chem. Phys 53 (1970) 1126-1130.

Friction Characteristics of Impregnated and Non-Impregnated Graphite against Cemented Carbide under Water Lubrication

RichHTML

可视化

摘要/Abstract

引用本文

使用本文

图/表 9

参考文献

相关文章 0

编辑推荐

Metrics

本文评价